Innovation New Jersey
  • Home
  • Our Coalition
    • Contact Us
  • News
  • Resources
    • State Supports
    • Federal Supports
    • Higher Ed Supports
  • Join Us

Innovation News

Everything Innovation. Everything New Jersey.
Follow us and stay connected.

NJIT Reports: EDC Company Creates Novel Device to Cut Tailpipe Emissions and Eliminate Testing Lines

11/4/2016

0 Comments

 
Newark, NJ — Tracey Regan reports that 4.0 Analytics, a research and development company in NJIT’s Enterprise Development Center (EDC), has developed a wireless emissions compliance and reporting technology for cars and trucks that alerts automobile owners in real time – on their own smart phone devices or computers – to engine and emission-system malfunctions that can lead to excessive tailpipe releases and poor performance.
 
By catching these problems early on, drivers should be able to substantially reduce emissions of pollutants, including greenhouse gases such as carbon dioxide, while spending less on repairs, getting better mileage and prolonging the lives of their cars.
 
Bringing Transparency to the Heart of the Vehicle
 
The technology has been greeted enthusiastically by a host of partners in Newark, including NJIT, Rutgers University-Newark, Essex County College, Seton Hall Law School and New Community Corporation, among other non-profit institutions and corporations. 
​A number of collaborators have begun testing it this fall in public safety and maintenance vehicles, among others in their fleets.
 
They are taking part in the pilot demonstration by installing 4.0 Analytics technology, a small interface device that fits under the dashboard of their cars and trucks.
 
The device captures raw data from the vehicle’s engine and emission systems and transmits it in real-time to cloud servers via secure cellular networks, where it is processed into actionable information with a proprietary software algorithm.
 
Fleet managers and other users will then review results from their own accounts on 4.0’s web-based platforms.
 
“It’s almost impossible to manage something if you can’t measure it,” explains Mark Scotland, the company’s CEO.  
 
Scotland continued, “Bringing transparency to the heart of the vehicle – its engine and emissions system – and understanding its behavior is the key to preserving the life of a very expensive asset. We do this by extracting raw data and processing results for end-users. We make it easier for fleet operators and motorists to establish baseline behavior, set goals for improvement and measure results against goals.”
 
Rutgers-Newark Backs 4.0 with Research Funds
 
Rutgers University-Newark is backing the pilot program with $70,000 from its Chancellor’s Seed Grant Program.
 
“This is an opportunity to reduce emissions and greenhouse gases. While many people feel that’s up to environmentalists and regulators, this technology allows individuals to play a part. We’re beginning with what we can do locally – with Rutgers, NJIT and other Newark institutions,” said Kevin Lyons, the principal investigator for the seed grant and program it funds, the Rutgers-Newark Green Zone 2020 EmCARS™ Initiative.
 
Lyons, an associate professor in Rutgers’ Department of Supply Chain Management, will assist the company in identifying new markets and support the “Rutgers Green Zone” launch and expansion. “This is a rare chance to be involved at the R & D level – and to practice what we preach about sustainability,” he added.
 
Two NJIT graduate students, Sandeep Raveeshbabu, who earned a master’s degree in electrical engineering in 2015, and Krutarth Patel, who is currently pursuing a master’s degree in computer science, helped develop the technology.
 
“We are thrilled that 4.0 Analytics, a rising star in our high technology and life sciences business center, was selected to receive this grant to demonstrate and refine its innovative technology,” said Judith Sheft, associate vice president for technology development at NJIT.
 
“Mark and his team are exemplary citizens of 21st century Newark, a city on the move with a growing population of future-focused entrepreneurs seeking to leverage the resources of New Jersey’s largest city, with its rich set of academic partners and vibrant tech sector.”
 
Sheft added, “This pilot program also aligns with our goal to make Newark a test-bed smart city.  We look forward to working with 4.0 Analytics and the other partners on this project and others.”
 
Taking Diagnostics Out of the Test Bay and onto the Road
 
Robert Gjini, assistant vice president of facility systems for NJIT, has agreed to enroll several university vehicles in the pilot program while also supporting efforts such as reducing idle time (when a vehicle’s engine is left on while in park), which wastes fuel, adds carbon emissions to the environment and shortens the life of some engine components. 
 
NJIT will help facilitate seminars and workshops on campus to apprise the university community and NJIT vendors about the dangers of vehicle emissions in urban communities.
 
Rutgers, which is interested in energy savings on its vehicles, will enroll pick-up trucks and vans in the pilot test, according to Patrick Harrity, the director of grounds and fleet operations at Rutgers.
 
Gloria Cowart, the company’s co-founder and operations director, said the demonstration “should show it is possible to reduce carbon emissions by 200,000 pounds for every 100 vehicles annually, while the timelier maintenance should also save drivers more than 10,000 gallons of gas.”
 
The company contends its technology would measure performance more accurately by providing car owners with information not available from garage-based analytics.
 
“The complexities of the vehicle’s on-board diagnostic system make it difficult to assess problems while it is in the repair bay and not on the road.  Having access to historical data while the vehicle is operating on the road can more precisely determine problems for a technician,” Scotland noted, adding, “These systems are also armed with anti-tamper mechanisms to prevent practices designed to subvert emissions-testing protocols. We designed our system so it cannot alter the federally mandated on-board computer system. We are able to see, evaluate and cross-reference data, and by doing so, we see anomalies that don’t make sense.”
 
The state conducts emissions tests to help reduce four pollutants related to vehicle combustion – hydrocarbons, nitrogen oxides, carbon monoxide and carbon dioxide.  “A growing number of studies,” Scotland noted, “conclusively show a correlation between urban areas with a high concentration of vehicles and higher rates of upper respiratory conditions, heart diseases and cancer.”
 
Proposing an Alternative to Manual Emissions Testing
 
New Jersey policymakers are now seeking ways to trim the cost of the program.  The state’s Motor Vehicle Commission (NJMVC), which runs it, and the state Department of Environmental Protection (NJDEP), which sets some policy parameters, have recently implemented measures such as eliminating pre-1996 vehicles from inspections and requiring cars that fail inspection to re-inspect them at private facilities, Scotland noted.
 
Through the Rutgers Green Zone project, 4.0 Analytics will present the state with a new, far-reaching option: phasing out manual emission testing entirely.  The plan is designed to save the state millions annually in contractor fees to run the program and add additional revenue by converting to electronic testing.  Motorists would be able to submit their emission compliance report each year from their mobile device, skipping a trip to the inspection facility.
 
“Our plan reduces costs for the state, is more convenient and less expensive for motorists, and would significantly reduce the carbon footprint. The technology exists today to begin this process,” Scotland said.
 
“According to state figures, we now spend about $41 million a year to test the 88 percent of vehicles that pass inspection. We have shown how the technology can reduce the cost of the state’s program by 70 to 90 percent. How is this possible? Begin by comparing the $20.29 it now costs per test to that of an electronic transmission.”
 
Federal guidelines are currently in place to allow state governments to transmit emission data remotely. Collaborators at Seton Hall Law School, one of the Green Zone partners, are researching New Jersey regulations to determine how to incorporate 4.0 Analytics’ plan into the state program. 
 
"We’re pleased to work on policies that may help the city of Newark and the State of New Jersey embrace cleaner energy technologies,” said David Opderbeck, director of the Gibbons Institute of Law, Science and Technology at Seton Hall Law School.
 
Rodney Brutton, director of workforce development at the Newark-based New Community Corporation, said the new technology would give students in the non-profit’s automotive training classes the chance to acquire valuable diagnostic and analytical skills.
 
“For us, this shows the diversity of jobs in the auto repair industry. The ability to focus on front-end analytics gives our students yet another career path,” Brutton said. “So participating was a natural fit for us.”
 
0 Comments



Leave a Reply.

    Do not miss a single innovative moment and sign up for our newsletter!
    Weekly updates


    Categories

    All
    3D Printing
    Academia
    Acquisitions
    Aerospace
    Agriculture
    AIDS
    Algae
    Alumni
    Animals
    Architecture
    Astrophysics
    Autism
    Awards
    Big Data
    Bioethics
    Biofuel
    Biomedical
    BioNJ
    Bioterrorism
    Bit Coins
    Brain Health
    Business
    Camden
    Cancer
    CCollege
    Cellular
    Centenary
    Chemistry
    ChooseNJ
    Climate Change
    Clinical Trials
    Cloud Tech
    Collaboration
    Computing
    Congress
    Coriell
    Council On Innovation
    Crowdfunding
    Cybersecurity
    DARPA
    Defense
    Degree
    Dementia
    Dental Health
    DOC
    DOD
    DOE
    Drew
    Drones
    Drug Creation
    Einstein's Alley
    Electricity
    Energy
    Engineering
    Entrepreneurship
    Environmental
    FAA
    Fairleigh Dickinson
    FDA
    Federal Budget
    Federal Government
    Federal Labs
    Federal Program
    Finance
    Food Science
    Fort Monmouth
    Fuel Cells
    Funding
    Genome
    Geography
    Geology
    Global Competition
    Google
    Governor Christie
    Grant
    Hackensack
    HackensackUMC
    Health Care
    Healthcare
    HHS
    HINJ
    Hospitals
    Immigration
    Incubator
    Infrastructure
    International
    Internet
    Investor
    IoT
    IP
    IT
    Jobs
    Johnson & Johnson
    K-12
    Kean
    Kessler
    Legislation
    Logistics
    Manufacturing
    Medical Devices
    Med School
    Mental Health
    Mentor
    Microorganisms
    Molecular Biology
    Montclair
    NAS
    Neuroscience
    Newark
    New Jersey
    NIFA
    NIH
    NIST
    NJBDA
    NJBIA
    NJ Chemistry Council
    NJCU
    NJDOLWD
    NJEDA
    NJEDge
    NJHF
    NJII
    NJIT
    NJMEP
    NJPAC
    NJPRO
    NJTC
    Nonprofit
    NSF
    OpEd
    Open Data
    OSHE
    OSTP
    Parasite
    Patents
    Paterson
    Patients
    Perth Amboy
    Pharma
    POTUS
    PPPL
    Princeton
    Prosthetics
    Ranking
    Rare Disease
    R&D Council
    Report
    Resiliency
    Rider
    Robotics
    Rowan
    Rutgers
    SBA
    Seton Hall
    Siemens
    Smart Car
    Smart Cities
    Software
    Solar
    Space
    SSTI
    Startup
    State Government
    STEM
    Stevens
    Stockton
    Subatomic
    Supports
    Sustainability
    Taxes
    TCNJ
    Teachers
    Telecom
    Therapy
    Thermodynamics
    Transportation
    Undergraduate
    USEDA
    Verizon
    Video Game
    Virtual Reality
    Water
    WHO
    William Paterson
    Women In STEM
    Workforce Development

Home   Coalition   News   Resources   Events   Join Us
Picture
Innovation New Jersey Coalition
10 West Lafayette Street
Trenton, NJ 08608
732-729-9619